GRC構件是一種水泥構件，通常作為裝飾品安裝在室外。因?yàn)樗枰?jīng)歷日曬風吹，所以在建設過程中需要安裝牢固，以防危險的發生。下面濟南GRC構件廠家為您講解下。

GRC component is a kind of cement component, which is usually installed outdoors as decoration. Because it needs to be exposed to the sun and wind, it needs to be firmly installed during construction to prevent danger. Now, the manufacturer of Jinan GRC components will explain it to you.

1、安裝輕質隔墻板，待墻板干燥后，方可進行表面除塵和粘接處理。(防止局部沉積、主體施工、其他外墻施工、墻灰施工、輕質隔墻裝修末)

1. Install light partition board, and conduct surface dedusting and bonding treatment after the wall board is dry. (Prevent local sedimentation, main body construction, other external wall construction, wall ash construction, and the end of light partition decoration)

2、為保證GRC輕質隔墻的剛性，建議縱向和橫向都使用鋼板網(0.8mm厚)，特別是高層建筑，并用長釘釘木板。

2. In order to ensure the rigidity of GRC light partition wall, it is recommended to use steel plate mesh (0.8mm thick) vertically and horizontally, especially for high-rise buildings, and use long nails to nail boards.

3、抹灰施工前用水潤濕墻面，然后用油漆滾筒將107膠水泥砂漿(107、水泥和沙子按1：2：3的比例配以適量的水和比例為1:2:3).用適量的水調成稀糊狀(涂層是標準的)，防止拉毛。待完全干透后，可使用普通水泥砂漿進行抹灰(二次抹灰每次不超過3-5mm)，但距上梁板1-2mm。

3. Before plastering, wet the wall with water, and then use a paint roller to apply 107 glue cement mortar (107, cement and sand are mixed with appropriate water in the proportion of 1:2:3) Use appropriate amount of water to make a thin paste (the coating is standard) to prevent galling. After it is completely dry, ordinary cement mortar can be used for plastering (the second plastering shall not exceed 3-5 mm each time), but 1-2mm from the upper beam plate.

4、石膏砂漿應選用中粗砂，摻入增塑劑，嚴格按比例混合均勻，石膏砂漿的水灰比不宜過大。否則，會形成空洞。尤其是水泥砂漿強度太高，使用細砂時，水分會蒸發。因此，彈性乳液需要使用425水泥。生產的彈性砂漿可變形，對墻體開裂有很好的控制。

4. The gypsum mortar shall be medium coarse sand mixed with plasticizer and mixed evenly in strict proportion. The water cement ratio of gypsum mortar shall not be too large. Otherwise, holes will be formed. Especially, the strength of cement mortar is too high, and the water will evaporate when using fine sand. Therefore, 425 cement is required for elastic lotion. The elastic mortar produced is deformable and has good control over wall cracking.

5、廚房和衛生間的隔墻一定要防水，離地1500mm的隔墻板面一定要涂防水劑。如板坑和管井。其余水管的進出水口需要做好防水處理。

5. The partition walls of kitchen and toilet must be waterproof, and the partition board surface 1500mm above the ground must be coated with waterproof agent. Such as plate pit and tube well. The water inlet and outlet of other water pipes shall be well waterproof.

在GRC構件安裝過程中，需要先安裝一個輕質隔音板，保證構建的剛性。值得一提的是，這個過程中需要對其做防水措施。更多相關事項就來我們網站http://m.dahuachengtao.com進行咨詢！

During the installation of GRC components, a light sound insulation board needs to be installed first to ensure the rigidity of the structure. It is worth mentioning that waterproof measures should be taken during this process. Come to our website for more information http://m.dahuachengtao.com Consult!